Procom FBD28T Instalační manuál stáhnout pdf

VENT-FREE GAS

FIREPLACE INSERT

OWNER’S OPERATION AND

INSTALLATION MANUAL

MODEL FBD28T

Questions, problems, missing parts? Before returning to your retailer, call

our customer service department at 1-866-573-0674, 8:00 am - 4:15 pm CST,

Monday through Friday or email customerservice@usaprocom.com

PFS

WARNING: If the information in this manual is not

followed exactly, a re or explosion may result causing

property damage, personal injury or loss of life.

— Do not store or use gasoline or other ammable va-

pors and liquids in the vicinity of this or any other

appliance.

— WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use any

phone in your building.

•

Immediately call your gas supplier from a neighbor’s

phone. Follow the gas supplier’s instructions.

• If you cannot reach your gas supplier, call the re

department.

—

Installation and service must be performed by a quali-

ed installer, service agency or the gas supplier.

WARNING: This appliance is equipped for Natural and

Propane gas. Field conversion is not permitted other than

between natural or propane gases.

1 2 3 4 5 6 ... 31 32

Shrnutí obsahu

Strany 1 - INSTALLATION MANUAL

VENT-FREE GASFIREPLACE INSERTOWNER’S OPERATION AND INSTALLATION MANUALMODEL FBD28TQuestions, problems, missing parts? Before returning to your retaile

Strany 2 - TABLE OF CONTENTS

www.usaprocom.com200014-01A10INSTALLATIONNOTICE: This heater is intended for use as supplemental heat. Use this heater along with your primary heating

Strany 3 - 3200014-01A

www.usaprocom.com11200014-01AINSTALLATIONNGLPINLET GAS PRESSUREMAX 1/2 PSIG (3.5 KPA)NGLPNGLPINLET GAS PRESSUREMAX 1/2 PSIG (3.5 KPA)NGLPFuel Selector

Strany 4 - SPECIFICATIONS

www.usaprocom.com200014-01A12INSTALLATIONBUILT-IN FIREPLACE INSTALLATIONFigure 9 - Rough Opening for Wall InstallationFigure 7 - Clearance to Combusti

Strany 5 - LOCAL CODES

www.usaprocom.com13200014-01AINSTALLATIONFigure 11 - Hood InstallationRemove 2 Screws from Top Firebox PanelInsulation BoardReplace 2 ScrewsHoodStep 1

Strany 6 - UNPACKING

www.usaprocom.com200014-01A14INSTALLATIONCONNECTING TO GAS SUPPLY CAUTION: Avoid damage to regulator. Hold gas regulator with wrench when connecting i

Strany 7 - 7200014-01A

www.usaprocom.com15200014-01AFigure 12 - Gas Connection* Purchase the optional CSA design-certied equipment shutoff valve from your dealer.The instal

Strany 8 - 30,000

www.usaprocom.com200014-01A16Figure 15 - Equipment Shutoff ValveCHECKING GAS CONNECTIONSOpenClosedEquipment Shutoff ValveControl Valve LocationControl

Strany 9 - VENTILATION AIR

www.usaprocom.com17200014-01ALog #1Log #2Log #3Log #5Burner PortsLog #4PRESSURE TESTING HEATER GAS CONNECTIONSINSTALLING LOGSFigure 18 - Installing Lo

Strany 10 - COMBUSTIBLES

www.usaprocom.com200014-01A18OPERATIONFOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not fol-low these instructions exactly, a re or explos

Strany 11 - 11200014-01A

www.usaprocom.com19200014-01A WARNING: You must oper-ate this heater with the screen in place. Make sure screen is installed before running heate

Strany 12 - 12.75"

www.usaprocom.com200014-01A2TABLE OF CONTENTSSafety ... 3Specications ...

Strany 13 - CAUTION: Do not operate

www.usaprocom.com200014-01A20INSPECTING BURNERSIMPORTANT: Owner’s should check pilot ame pattern and burner ame pattern often. Incorrect ame patt

Strany 14 - CONNECTING TO GAS SUPPLY

www.usaprocom.com21200014-01AApprox. 3"-6" Above Top of LogsMore Than 8" Above Top of LogsApprox. 3"-6" Above Top of LogsMore

Strany 15

www.usaprocom.com200014-01A22Use a vacuum cleaner, pressurized air, or a small, soft bristled brush to clean.A yellow tip on the pilot ame indicates

Strany 16 - CHECKING GAS CONNECTIONS

www.usaprocom.com23200014-01ATROUBLESHOOTING WARNING: If you smell gas:• Shut off gas supply.• Do not try to light any appliance.• Do not touch any

Strany 17 - INSTALLING LOGS

www.usaprocom.com200014-01A24Problem Possible Cause Corrective ActionODS/pilot lights but ame goes out when control knob is released.1. Control k

Strany 18 - BATTERY INSTRUCTIONS

www.usaprocom.com25200014-01ATROUBLESHOOTINGProblem Possible Cause Corrective ActionSlight smoke or odor dur-ing initial operation1. Residues from man

Strany 19 - LIGHTING INSTRUCTIONS

www.usaprocom.com200014-01A26PARTSMODEL FBD28T2028912287421111819313141516176569752310

Strany 20 - MANUAL LIGHTING PROCEDURE

www.usaprocom.com27200014-01APARTSMODEL FBD28TThis list contains replaceable parts for your heater. When ordering replacement parts, follow the instru

Strany 21 - BURNER PRIMARY AIR HOLES

www.usaprocom.com200014-01A28ACCESSORIESPurchase these heater accessories from your local dealer. If they can not supply these acces-sories, contact P

Strany 22 - CARE AND MAINTENANCE

www.usaprocom.com29200014-01ASERVICE HINTSWhen Gas Pressure Is Too Low• pilot will not stay lit• burners will have delayed ignition• replace will

Strany 23 - 23200014-01A

www.usaprocom.com3200014-01ASAFETYIMPORTANT: Read this owner’s manual carefully and completely before trying to assemble, op-erate, or service thi

Strany 24 - TROUBLESHOOTING

www.usaprocom.com200014-01A30NOTES____________________________________________________________________________________________________________________

Strany 25

www.usaprocom.com31200014-01ANOTES____________________________________________________________________________________________________________________

Strany 26 - MODEL FBD28T

200014-01Rev. A06/13REGISTER YOUR PRODUCT AT WWW.USAPROCOM.COMIMPORTANT: We urge you to register your product within 10 days of date of installation,

Strany 27

www.usaprocom.com200014-01A41. Do not place Propane/LP supply tank(s) inside any structure. Propane/LP supply tank(s) must be placed outdoors.2. Thi

Strany 28 - REPLACEMENT PARTS

www.usaprocom.com5200014-01AQUALIFIED INSTALLING AGENCYOnly a qualied agency should install and replace gas piping, gas utilization equipment o

Strany 29 - TECHNICAL SERVICE

www.usaprocom.com200014-01A6PRODUCT IDENTIFICATIONFigure 1 - Vent-Free Fireplace InsertHoodLogsScreenHeater Controls (Behind Panel)WATER VAPOR: A BY-P

Strany 30 - 200014-01A30

www.usaprocom.com7200014-01AAIR FOR COMBUSTION AND VENTILATION WARNING: This heater shall not be installed in a conned space or unusually tight const

Strany 31 - 31200014-01A

www.usaprocom.com200014-01A8DETERMINING FRESH-AIR FLOW FOR HEATER LOCATIONDetermining if You Have a Conned or Unconned Space4. Compare the maximum

Strany 32 - WARRANTY

www.usaprocom.com9200014-01AVENTILATION AIRVentilation Air From Inside BuildingAIR FOR COMBUSTION AND VENTILATIONOutlet Air Ventilated Attic Outlet A